Evo Powersports Can-Am Maverick X3 Desert Storm Gen3 Turbo System 2.0

Evo Powersports Can-Am Maverick X3 Desert Storm Gen3 Turbo System 2.0

Gen3 TiAL Turbochargers with revised ECU calibrations have arrived! Two Versions available and both Turbochargers are direct replacement for the OEM Turbo, meaning no custom exhaust fabrication is needed.

68mm Compressor with X2C Cover 76mm Anti-Surge (Ported) Inlet

• Up to 420HP with Stock ECU
• Up to 450HP with MoTec ECU*

71mm Compressor with X2C Cover and 76mm Anti-Surge (Ported) Inlet: Up to 550 horsepower*

• 420HP with Stock ECU
• 420-550HP with MoTec ECU*

*These power goals require additional supporting modifications including a complete Stage 2 Engine Build.

Many hours of R&D were spent testing and refining the new Gen3 Desert Storm Turbo Systems. These latest generation 68mm turbos net about 4% more horsepower than the Gen1 and Gen2 X1C cover turbos. The additional horsepower comes from increased efficiency of the larger compressor housing combined with the recently revised compressor aerodynamics. The 68mm version has enough cfm for 450 horsepower with quick spool characteristics. The 71mm is capable of 550 horsepower for all-out mind-bending acceleration with slightly slower turbo spool. Both versions have a billet aluminum, ball bearing CHRA to ensure maximum durability under extreme boost power levels.

Power Level Explained

EVP has been tuning and building X3’s for longer than any other company period. We know the limitations of each OEM engine component and build each system to fit within these constraints. Each power level we offer is designed to be easily upgradable to the next Level with minimal hardware changes so as your performance requirements change, upgrading to the next level is easy. Also, most of the turbo systems have tuning available for a variety of fuels including 91 octane, so you're not stuck with race gas or E85 tunes all the time. Our Power Levels are so well-dialed that to change to a pump fuel setup, all that is required in most cases is to drain the fuel and reFlash the ECU to the tune that corresponds to the fuel octane!

All Power Level Includes

• Desert Storm Gen3 68mm Turbocharger
• Factory ECU Flash with optional 2-Step Launch Control upgrade (an EVP Exclusive)
• EVP Fuel Pump Upgrade Kit with pnp Adapter Harness
• Silicone Turbo-to-Intercooler Upper Charge Tube with Clamps
• Silicone Intercooler-to-Throttle Body Charge Tube with Clamps
• Genuine Bosch Fuel Injector Set (Direct Replacement)
• Genuine Bosch 4-Bar Map Sensors
• EVP V-Flow Intake with Custom Big Turbo Boot
• EVP Billet Vent-to-Atmosphere BOV Kit

Power Level: DS-280

280HP on 100 Octane fuel! For stock engine vehicles. This kit was designed for the customer who wants substantially more power than the OEM turbocharger can deliver with minimal hardware changes. It's also an easy upgrade for those who are already running our 2017-2021 Big Injector Flash (as some components will be reused). A great kit for those wanting to build up to their ultimate Power Level in stages.

Includes everything listed above and:

• 24 psi of Boost on 100 Octane Fuel
• 91 & 100 Octane Tunes (No hardware changes required to switch between tunes)

Power Level: DS-320

320+HP on 110 Octane or E85 fuel! For stock engine vehicles with EVP head studs (included). This kit was designed for the customer who is willing to upgrade a few more components which will allow them to make another 40HP over the DS-280 kit. This is also a great building-block for our higher Staged Turbo Systems.

Includes everything found in DS-280 and:

• 29 psi of Boost on 110 and E85 Fuel
• 91, 100 & 110 Octane and E85 Tunes (No hardware changes required to switch between tunes)
• EVP Race Intercooler
• "The Clamp" Plenum Reinforcement Brace (Allows use of the OEM plenum which can break without reinforcement)
• ARP2000 9mm Head Stud Kit
• If upgrading to a higher Power Level in the future, our EVP 9-10mm Custom Age 625 Head Stud Kit can be substituted for an additional upgrade charge

Power Level: DS-355SCR

Ludicrous speed enabled! 355HP on 110 and E85 fuel - This is by far the most fun and popular big turbo system we sell! Responsive on the bottom end with an eye-watering top end performance. It's an easy upgrade from the DS-320; only change injectors and head studs*. This turbo system is designed for stock or lightly built engines and includes EVP Custom Age 625 Head Studs (included). MoTec Standalone ECU Packages Available.

*Requires STM Primary Clutch

Includes everything found in DS-320 and:

• 34 psi of Boost on 110 and E85 Fuel
• 91 & 110 Octane and E85 Tunes (No hardware changes required to switch between tunes)
• EVP XR Series Custom Age 625 Head Stud Kit
• These are 9mm at the block so they are direct replacement but 10mm where they come through the head. The nut is the weakest part of the stud so this gives us additional clamping force on the head while still being direct replacement; an EVP Exclusive.
• Injector Dynamics High-Flow Injectors

Power Level: DS-395SCR

395 horsepower on E85 fuel! For lightly built engines (CP/Carrillo pistons and connecting rods). Includes a plug and play rising rate fuel system (included). Motec Standalone ECU package available.

Included in the box:

• All items in the DS-355 plus
• 37-39 psi boost on E85
• Factory ECU tuned with EVP launch control option.
• EVP Race intercooler
• EVP Custom Age 625 head studs.
• These are 9mm at the block, so they are direct replacement, but 10mm where they come through the head. The nut is the weakest part of the stud, so this gives us additional clamping force on the head while still being direct replacement. These studs are only available from EVP.
• Injector Dynamics high flow injectors
• Rising rate fuel system
• EVP Torrent F high flow intake plenum
• 71mm turbo optional

Required but not included:

• Full Exhaust
• Clutching

ALL POWER LEVELS BELOW REQUIRE COMPLETE ENGINE BUILDS

Our 420 & 500 Power Level Kits incorporate complete engine builds which pushes the limits of the turbocharger while delivering unmatched power and performance. These Levels are for the EXTREME customer that needs to have ALL that this turbo has to offer. Please call us and ask for Dan at 715-781-6541 in our race department for additional details and purchase.

Power Level: DS-420X

Requires an EVP Stage 2 Closed Deck, Sleeved Block. Factory ECU tuned with EVP Launch Control Option. E85 only. 40 psi of boost on E85.

Includes everything found in DS-355SCR and:

• Rising Rate Fuel System
• EVP Torrent-F High Flow Intake Plenum
• EVP XR Series Camshafts
• 68 or 71mm Turbocharger
• Motec Standalone ECU package available

Power Level: DS-500RX

Requires an EVP Stage 2 Closed Deck, Sleeved Block and EVP Stage 2 head with oversize valves. With EVP 2-Step Launch Control option. E85 only. 45+ psi of boost on E85. Motec ECU package required.

Includes everything found in DS-450RX and:

• 71mm Turbocharger

Additional Information

• All turbo systems require a full exhaust and clutching which can be purchased separately.
• 2017 Models require the 2018+ OEM fuel pump assembly. This must be purchased prior to Turbo System purchase and install.
• Please call our sales department for custom configurations. If you already own some of the kit components, the retail price of those items can be directly subtracted from the turbo upgrade kit price. For example if you have an EVP big injector, stock turbo tune with a V-Flow intake, the injector set and V-Flow intake retail prices can be subtracted from the kit cost.